WhisperKool Extreme 4000 User Manual

Kit Two: 9 Power Cord 9 Self-Tapping Screws (6) 9 Drain Line 9 Mounting Flange Pieces (4) 9 Bottle Temperature Probe 9 Insulation Foam (4 stri

Preparing the Wine Cellar The performance and life of your WhisperKOOL Extreme Series Unit are contingent upon the steps you take in preparing the wi

Vapor Barrier Vapor Barrier is REQUIRED to prevent the intrusion of water vapor, which keeps the cellar at the correct temperature and humidity. Six-

Installation Electrical Needs The WhisperKOOL Extreme System requires a dedicated 115-volt 15-amp circuit. The unit draws a large amount of amps at

Push Button Circuit Breaker In case the unit should lose power, press the reset button and attempt to turn unit back on. Check the home/main circui

Through-the-Wall Installation (Without Ductwork) Test the Unit Prior to Installation To prepare it for testing before installation in wall: 9 Remov

Standard Mounting Arrangements Typical Through the Wall These illustrations are suggested mounting styles and act as guidelines only. They do not r

Cutting the Hole for the WhisperKOOL Unit Tools Needed Locate the center of the wall upon which the unit will be installed. Using a stud finder, lo

Using a saw, cut along the uppermost horizontal line until your saw reaches the stud. Turn the saw around, inserting it into the cut

Now you have to make the same hole on the other side of the wall. Since you already have one hole, this is an easy process. Using a nail, mark all f

Applying Insulation Tape Locate the four precut pieces of black foam tape included with the system. There should be two larger pieces and two smaller

Placement of Unit Slide the unit from either the inside or outside wall into your wine cellar with the outer flange flush to the wall. You will need

Exterior Grill Installation Exterior grill is required on all installations where the condenser side of the unit is exposed to the outside of the dwe

Ducted Installation Use ductwork to connect the unit to the supply and return outlets in the wine cellar. Use only insulated ductwork to minimize coo

Using Ductwork Cold Air to/from Wine Cellar 9 Remove supply air grille to install ductwork between WhisperKOOL Extreme unit and the cellar. 9 Conn

Flexible and Easy Installation Fully Ductable System The ventilation system is ideal for ducting. The optional collars fit standard ventilation duct

26

Liquid Measuring Thermostat System Power Switch Turns the unit on/off. Hi-Temp Light Lights red when the back side of the unit reaches 130°F. It

Thermostat Instructions Icon Normal Operation Mutes the audible alarm (buzzer) and deactivates the alarm rela

ICON FUNCTION DESCRIPTION ON Normal Operation OFF BLINK COMPRESSOR ON when compressor starts. Flashes when the activation of compressor is delayed b

Copyright © 2007. Vinothèque Wine Cellars. All rights reserved. This manual, the product design, and the design concepts a

Controller Alarms Code Icon Display Alarm Relay Buzzer Description rE flashing on on virtual control probe fault E0 flashing of

Maintenance Schedule Monthly 1. Check Filters 2. Check for unusual noise or vibration. Quarterly Clean Filters:

Troubleshooting Guidelines Unit Does Not Come On Controller Display Panel Light is Not On Possible Cause Solution Unit is not plugged in M

Cellar Temperature is too Cold Temperature is too Low when Unit is ON Possible Cause Solution Controller set too low Change set point on co

Technical Assistance Vinothèque Customer Service is available Monday through Friday from 8:00AM to 4:00PM Pacific Time. The customer service repres

35

Installation Terms and Conditions WhisperKOOL XLT/Extreme Cooling System ATTENTION: PLEASE READ THESE TERMS OF USE CAREFULLY BEFORE INSTALLING YOUR W

supply, or attempted repair by anyone other than a technician approved by Vinothèque to service the product. This warranty does not cover products sol

7. Customer Service Vinothèque’s customer service department is available Monday through Friday, from 8:00AM to 4:00PM PT by calling 1-800-343-9463.

Vinotheque Wine Cellars 1738 E. Alpine Avenue Stockton, CA 95205 800-343-9463

Contents Introduction... 7 What Is the WhisperKOOL Ex

Unit Does Not Come On... 32 Unit Leaks Water...

Introduction Congratulations and thank you for purchasing a WhisperKOOL Extreme cooling unit. We believe it to be the best wine cellar cooling unit o

Features and Benefits Liquid Temperature Measuring Probe The unit accurately measures the temperature of wine in the cellar using a liquid temperatur

Customer Warranty Registration PLEASE COMPLETE AND RETURN THE WARRANTY CARD UPON RECEIPT OF THE UNIT. By completing the Product Registration Card,